INTERSTATE 81 LANE WIDENING CONSTRUCTION PROJECT EXIT 137 TO EXIT 141 – The $179 million design-build project to widen both directions of I-81 between mile markers 136.6 and 141.8 from two to three lanes is underway. Work is being performed along a five-mile section of both northbound and southbound Interstate 81 in Roanoke County and the city of Salem. Barrier wall is in place along the shoulders. Two lanes of I-81 traffic in each direction are expected to remain open during the project with periodic lane closures scheduled during nighttime hours or outside of peak travel times as needed. Drivers can expect the following lane closures and upcoming traffic impacts in this area on northbound and southbound I-81:
ADDITIONAL TRAFFIC IMPACTS:
LANE CLOSURES: Alternating left and right lane and shoulder closures during nighttime hours between 8 p.m. and 6 a.m., Sunday through Thursday, are possible. Lane widths will be reduced to 11 feet. Nightly lane closures may be in place along the right lane with possible nightly ramp narrows as needed for guardrail and shoulder strengthening.
LANE CLOSURES scheduled as follows: Tuesday, January 7 – Northbound left lane closure from mile marker 147.5-148.74. Wednesday, January 8 – Northbound right lane closure from mile marker 147.5-148.74. Thursday, January 9 – Northbound right and left lane closures from mile marker 147.5-148.74.
FLAGGING OPERATIONS: Flagging operations possible on Route 635 and Route 619.
UNEVEN PAVEMENT: Drivers may experience some uneven pavement and rough surface throughout the project.
TRAFFIC SHIFTS: Drivers may experience periodic lane closures, narrow ramps or quick merges into traffic onto Thompson Memorial Drive from the southbound or northbound exit ramps of exit 140 off of I-81. Work zone located at bottom of the ramp for work on the I-81 bridge at the underpass.
TRAFFIC SHIFTS ON WILDWOOD ROAD: Expect a work zone with traffic shifts and narrow width on Wildwood Road after exiting I-81 southbound on exit 137 heading towards Salem. Southbound and northbound I-81 exit and entrance ramp narrows are possible at Route 311.
WORK ZONE SPEED: Drivers should adhere to posted 60 mph speed limits in the work zone and allow space when following a vehicle. Narrow spacing in lanes due to barrier walls, lack of shoulders and lane shifts in various locations are present.
The project also includes replacing six bridges, widening two bridges, installing approximately 2.6 miles of sound barrier walls along northbound I-81, improving the southbound exit 137 off-ramp intersection at Wildwood Road and adding interchange lighting at exits 137, 140 and 141. Expected completion in early 2026.
I-81 NB & SB DECK OVERLAY AT PEAK CREEK MILE MARKER 95.7 – Repair work is underway on the northbound and southbound bridges on I-81 over Peak Creek near mile marker 95.7. This repair work will require nighttime single lane closures for the duration of the project. Lane closures may occur nightly from Sunday night through Friday mornings between 8 p.m. and 6 a.m. For the deck overlay process, lane closures may be in place between Sunday nights through Friday mornings. For the southbound lanes these will occur between 7 p.m. and 10 a.m., and for the northbound lanes between 6 p.m. through 9 a.m. Details on these closures will be listed below on a weekly basis. Estimated completion is summer 2025.
Deck work postponed due to cold weather. This may resume in March. Alternating nighttime northbound and southbound left and right lane closures may or may not be in place from mile marker 96 to 94 during the hours of 8 p.m. and 9 a.m. while other work on the project continues.
I-81 NORTHBOUND AT EXIT 105 NEW RIVER BRIDGE REPLACEMENT IN MONTGOMERY COUNTY – Traffic on northbound I-81 has been switched onto the newly constructed bridge over the New River at the Montgomery/Pulaski County line. Lane and shoulder closures may be in place near exit 105. Lane closure may be in effect during the week from 8 p.m. to 7 a.m. Shoulder closures may be in effect at any time during the week. Slow rolls may be performed on I-81 in the north and southbound lanes from mile marker 98 to 109. Speed limit is reduced to 60 miles per hour in the work zone. Shoulder closures will remain in place through the duration of the project.
LANE CLOSURES: Nighttime left lane closures may be in place on I-81 northbound or southbound between mile marker 106 and 104 from 8 p.m. to 6 a.m. the following morning.
ROUTE 605: Alternating lane closures and flagging operations may be present on Route 605, located under the New River Bridge, for paving operations and work overhead on the bridge.
SLOW ROLLS: Slow rolls may be utilized periodically on both the northbound and southbound lanes from mile marker 98-109 for structural steel deliveries and setting beams.
I-81 IMPROVEMENTS FROM MILE MARKER 143 TO 151 – Periodic lane closures may be in place during nighttime hours 9 p.m. to 6 a.m. on northbound and southbound I-81 for survey and preparation work for an upcoming widening project along I-81.
I-81 BRIDGE DECK REPAIRS – Weather permitting, crews will repair bridge decks on Interstate 81 between mile markers 170 to 89, right and left lane closures will be in place northbound and southbound during nighttime hours, 9 p.m. to 6 a.m. the following morning. Drivers should watch for signs and expect possible delays.
INTERSTATE 581
I-581 PATCHING OPERATIONS – Weather permitting, beginning August 18, crews will perform paving and patching operations. Lane closures will be in place northbound and southbound, Sunday through Thursday, during nighttime hours, 7 p.m. to 7 a.m. the following morning. Drivers should watch for signs and expect possible delays.
INTERSTATE 77 (CARROLL COUNTY)
I-77 PAVING & PATCHING OPERATIONS – Weather permitting, crews will perform paving and patching operations on Interstate I-77. Right, left and center lane closures will be in place northbound and southbound, Monday through Friday, during nighttime hours, 7 p.m. to 5 a.m. the following morning. Drivers should watch for signs and expect possible delays.
I-77 BRIDGE DECK REPAIRS – Weather permitting, crews will perform paving operations on Interstate 77. Right and left lane closures will be in place northbound and southbound during nighttime hours, 7 p.m. to 6 a.m. the following morning. Drivers should watch for signs and expect possible delays.